Powertec30

 

The Powertec system enables to clean and sanitize restrooms by spraying a fluid foam, rinsing and vacuuming. It uses a little amount of water and it is suitable for frequent interventions, even daily.

It is the ideal solution for cleaning contractors who are looking for a machine to be left at each customer’s facility.

 Power supply
cable 
 Complete cleaning/ Quick sanitization
 100m²+15 sanitary fixtures in 20/3 minutes
 Tank capacity
30/30 liters

Video Player is loading.
Current Time 0:00
Duration -:-
Loaded: 0%
Stream Type LIVE
Remaining Time -:-
 
1x


Powertec30 is a patented machine for cleaning and sanitizing small and middle-sized restrooms, in areas open to public. It combines spraying of a fluid foam, rinsing and vacuuming. With Powertec30 restrooms can be completely cleaned, sanitized and left perfumed and dry in a short time, making the cleaning operations more pleasant and effective as well.

Using the machine is immediate and does not require any training for the operator.

Small and light, it can be easily stored or carried from place to place.

The cleaning process is carried out through four stages:

  1. Spraying of foam on all the surfaces to be cleaned (walls, sanitary fixtures, showers and panes),
  2. Chemical action against dirt and bacteria,
  3. Rinsing with clean water,
  4. Floor washing with injection-extraction system.

The manual gun allows you to spray fluid foam and to rinse surfaces with clean water.

The special wand included allows you to clean hard floors with the injection-extraction system: a chemical solution is sprayed on the floor and vacuumed. The dirt detached from the floor is completely removed thanks to the powerful vacuum and collected in the recovery tank.

In few second the floor gets perfectly dry and with no effort. It is possible to inject and vacuum simultaneously, or to inject, brush and then vacuum. A specific bristle on the vacuum head allows you to brush efficiently very dirty floors.

It is not necessary to manually dose the chemical, because the machine automatically picks up the right quantity of chemical from the chemical tank and mixes it with clean water, taken from the water tank.The chemical is always used in the correct quantity and never wasted.   

Powertec30 allows a sanitizing chemical to be nebulized to quickly sanitize previously cleaned surfaces and environments. It is possible to use two nebulization systems:

a) nebulization@100micron - for surfaces

b) turbo-nebulization@50micron - for surfaces and environments

Nebulization@100micron

With a specific manual gun it is possible to nebulize a sanitizing chemical in the form of a liquid solution in 100 micron particles. With the nebulization at 100 micron the particles deposit evenly on the surfaces wetting them slightly and after a few minutes the particles evaporate, leaving the surfaces dry. In this way the chemical is able to act for the necessary time to carry out its sanitizing action. This is the ideal solution to quickly sanitize all washable surfaces.

Turbo-nebulization@50micron

Using a specific hand gun for turbo-nebulization@50micron it is also possible to deliver a mixture of air and very fine particles of pure sanitizing product with a diameter of only 50micron.

Their small size allows the particles to remain in suspension in the sanitizing air jet, which can reach points 4 meters away from the operator. By directing the jet appropriately, it can easily reach every point in the room and saturate small rooms quickly and evenly

With turbo-nebulization@50micron, the particles wet surfaces very little, leaving them only slightly damp for a few minutes. In this way, the product is able to act for as long as it takes to perform its sanitizing action in all points.

Powertec30 can be used in many places:

  • Restaurants, fast-foods, pubs, discotheques, motorways cafés
  • Offices, factories
  • Shopping centres, exhibition halls
  • Cinemas, theatres, stadiums, arenas
  • Nursing homes, hospitals
  • Schools, universities,
  • City public WC, public showers, barracks
  • Ferries, cruise ships, airports, railways stations,
  • Fitness centres, swimming pools, saunas, spas, hotels
  • Portable restrooms 
  • Any other restroom open to public

Santoemma patented Powertec system is the best solution to the problem of cleaning and sanitizing restrooms in places where there is a need for frequent, even daily cleaning.  It offers several advantages when compared to any other cleaning system:

  1. Better cleaning and sanitising result: foam does not immediately fall onto the floor, but stays on the surfaces where it has been sprayed for some minutes. This ensures both the cleaning and sanitizing action. Laboratory tests certify that using the machine with specific chemicals  allows you to kill 99,9% of bacteria.
  2. Visual effect of foam: foam covers in white all the surfaces where it is sprayed such as walls, sinks, fixtures. The operator can therefore check that every corner has been covered, for a complete action in every point.
  3. The greatest hygienic safety for the worker, who does not come in contact with the surfaces and the objects to be cleaned and who does not get wet by the bouncing water, because rinsing is done with low pressure.
  4. Reduced labour for the worker: manual work is reduced to a minimum since the dirt is removed by the chemical action of foam and the following rinsing action.
  5. This system, more comfortable and hygienic, gives a greater fulfilment to the worker.
  6. Saving of time: while foam acts on the surfaces where it has already been sprayed, the worker is free to operate on the next surface. Therefore, even a big room can be completely cleaned quickly and with no idle time.
  7. Detergent saving: the chemical is used without waste because it does not immediately fall onto the floor.
  8. Reduced power consumption: the machine requires little electrical power and therefore it can be used in any places.
  9. Reduced water consumption: Santoemma systems, rinsing with low pressure, require a minimal quantity of water. This avoids the flood of rooms, allows a longer working autonomy and offers the immediate availability of the rooms that have been cleaned.
  10. The machine can be used also in places where there are no drains because it can completely vacuum the water that remains on the floor after rinsing.

  • The machine has a small size, therefore it is easy to carry from place to place and can be stored in a small room.
  • Filling with clean water can be easily done with a hose connected to the tap.
  • The discharge of dirty water is carried out easily thanks to a long hose. 
  • The use of the machine is immediate and does not require any training. Just one lever is located on the control panel, to select solution or clean water spraying.
  • Using optional accessories, a chemical can be nebulized with the same machine to quickly sanitize previously cleaned surfaces and environments.
  • Using optional tools, Powertec30 can be used as an injection-extraction machine, for carpet or upholstery cleaning.

Approximate performance: room with 100m² of tiles
+ 15 sanitary fixtures
1) Complete cleaning and sanitizing:
    Time:

    Chemical consumption:
    Water consumption:
    Defoamer consumption:
20 min
500 gr (5gr/m²)
30 liters
-
2) Quick sanitization:
     2a) with Nebulization@100micron
    
    Time:
        Chemical consumption:
        Water consumption:

3 min
250 gr (2,5gr/m²)
5000 gr (50gr/m²)
     2b) with Turbo-Nebulization@50micron
        Time:
         Chemical consumption:
        Water consumption:

3 min
200 gr (2gr/m²)
-
Recovery tank capacity: 30 litres
Clean water tank capacity:
30 litres
Chemical dilution:
Pre-set around 4%
Continuous filling system: YES

Vacuum motor:
Power:
Maximum waterlift:
Maximum air-flow:

2 stages 
1000 W
2200 mm H2O
50 l/sec.

Pump with bypass:


Power:
Max pressure:

Rinse pressure:

Rinse water-flow:

Membrane,
int. bypass
90W
14 bar
7 bar
3 l/min

Cleaning width (hard floors): 400 mm (with NS400P)
Cable length: 10 m
Spray hose/Vacuum hose length: 5/5 m
Weight (machine body): 35 kg
Weight (packaged machine): 47 Kg
Dimensions: cm 38 x 60 x 78 h
Package dimensions: cm 54 x 90 x 103 h
Units/pallet:

1pz/pallet

(cm 54 x 90 x 103 h)

Standard color: Blue
Tank construction: High density polyethylene
Noise pressure level (3m/1m - ISO3744): 65 dB(A) / 71 dB(A)
Power supply: cable - 220-240V 50-60Hz
(other voltages on request)
International patents: EP 4243663 + US 18/036210 + CN 202180076065.2


 

Recommended accessories and devices

In order to optimize the results that can be obtained by this model, we suggest the adding the following accessories and special devices:

Other compatible accessories and devices

Below are listed all the accessories and devices that can be used with this machine

© 2017-2024 Santoemma
Professional cleaning systems
SANTOEMMA S.r.l
Via Piave, 22/C
20016 Pero (Milano) Italy
Tel: +39 02 3391 2487
e-mail: info@santoemma.com
P.IVA: IT11512020154
SOCIAL
Follow us:
LGMDSMXS